亚洲国产精品一区二区美利坚,国产精品自在线拍国产电影

站內搜索

新聞資訊

公司新聞行業動態

熱點

自動上料平口攪拌機多種方量可供選擇

2022-12-23

混凝土自動上料攪拌車的功能有哪些？

2022-12-19

混凝土自動拌料車移動式可自行走戶外施工

2022-12-16

自上料攪拌車企業這么多，買車的時候應該看哪方面？

2022-12-12

關于山汽

聯系人：劉老師

電話：400-879-1999

公司：山東山汽工程機械（集團）有限公司

地址：山東省萊州市206國道與308省道交叉口東南50米

自動攪拌車使用時的注意事項

所屬分類：行業動態 發布時間：2020-06-06 來源：http://www.842233.cn/ 瀏覽量：0

自動攪拌車是用來運送混凝土的專用卡車，在對它進行操作的時候需要注意一些問題，才能發揮它應有的功能，接下來就給大家介紹一下它在操作時的注意事項。

The automatic loading mixer truck is a special truck used to transport concrete. When it is operated, some problems need to be paid attention to in order to play its due functions. Next, we will introduce its precautions in operation.

1、自動攪拌車在水泵工作時，禁止空轉，連續使用時不要超過15分鐘。

1. When the water pump of the automatic feeding mixer works, it is forbidden to idle, and it shall not be more than 15 minutes in continuous use.

2、起動攪拌車之前，應把攪拌筒操作手柄放在“停止”位置。

2. Before starting the mixer, place the operating handle of the mixing drum in the "stop" position.

3、攪拌車起動發動機后，應使攪拌筒在低速下轉動10分鐘左右，使液壓油溫升到20℃以上后方可工作。

3. After the mixer starts the engine, the mixing drum shall be rotated at low speed for about 10 minutes to make the hydraulic oil temperature rise above 20 ℃ before operation.

4、自動攪拌車在露天停放時，裝料前應將攪拌筒反轉，將積水和雜物排出，以保證混凝土的質量。

4. When the automatic loading mixer is parked in the open air, the mixing drum shall be reversed before loading, and the accumulated water and sundries shall be discharged to ensure the quality of concrete.

5、攪拌車在運輸混凝土?xí)r，要保證滑斗放置牢固，防止因松動造成擺動，在行進中打傷行人或影響其它車輛正常運行。

5. When transporting concrete, the mixer truck shall ensure that the sliding bucket is placed firmly to prevent swinging caused by looseness, hurting pedestrians or affecting the normal operation of other vehicles in the process of moving.

6、攪拌車裝運攪拌好的混凝土?xí)r，攪拌筒轉速為2-10轉/分，在運輸過程中，平坦路面上攪拌筒轉速保證在2-3轉/分，行駛在側傾坡度大于50的路面，或左右晃動較大的路面時，應停止攪拌旋轉，待路況好轉后再恢復攪拌旋轉。

6. When the mixer truck transports the mixed concrete, the rotating speed of the mixing drum is 2-10 rpm. During the transportation, the rotating speed of the mixing drum is guaranteed to be 2-3 rpm on the flat road surface. When driving on the road surface with a slope greater than 50, or the road surface with a large left and right shaking, the mixing rotation shall be stopped and the mixing rotation shall be resumed after the road condition is improved.

7、混凝土攪拌車出料完畢，應立即用隨車的軟管放水將進料口、出料斗及出料溜槽等部位沖洗干凈，排去粘結在車身各處的污物及殘留混凝土，再向攪拌筒內注水150-200L的清水，在返回途中要讓攪拌筒慢速轉動，以清洗內壁，避免殘余料渣附在筒壁和攪拌葉上，并在再一次裝料前將這些水放掉。

7. After the concrete mixer is discharged, immediately flush the inlet, outlet hopper, discharge chute and other parts with the hose attached to the mixer, remove the dirt and residual concrete stuck on the vehicle body, and then fill the mixer with 150-200l clean water. On the way back, let the mixer rotate slowly to clean the inner wall and avoid the residual slag attached to the wall and mixing blade Drain the water before loading again.

8、混凝土自動上料攪拌車運送混凝土的時間不能超過攪拌站規定的時間。運送混凝土途中，攪拌筒不得長時間停轉，以防混凝土產生離析現象。司機應時常觀察混凝土情況，發現異常及時通報調度室，申請做出處理。

8. The delivery time of concrete by the automatic concrete loading mixer shall not exceed the time specified by the mixing plant. During the transportation of concrete, the mixing drum shall not be stopped for a long time to prevent the concrete from segregation. The driver shall often observe the concrete condition, timely report to the dispatching room in case of any abnormality, and apply for handling.

9、攪拌車車內裝有混凝土?xí)r，在現場停滯時間不得超過1小時，如超時應立即要求現場負責人給予及時處理。

9. When the mixer truck is equipped with concrete, the dead time at the site shall not exceed 1 hour. If it exceeds the time limit, the person in charge of the site shall be required to deal with it in time.

10、攪拌車運送混凝土塌落度不得低于8cm。從混凝土入罐到排出，氣溫高時不得超過2小時就需要排出，陰雨天氣溫度低時，不得超過2.5小時。

10. The slump of concrete transported by mixer truck shall not be less than 8cm. From the time when the concrete is put into the tank to the time when it is discharged, it shall not be discharged for more than 2 hours when the temperature is high, and it shall not be discharged for more than 2.5 hours when the temperature is low in rainy days.

11、自動上料攪拌車在排出混凝土之前，應使攪拌筒在10-12轉/分的轉速下轉動1分鐘，再進行排料。

11. Before discharging the concrete, the automatic loading mixer shall rotate the mixing drum at the speed of 10-12 rpm for 1 minute before discharging.

12、混凝土攪拌車運送混凝土?xí)r，發動機轉速在1000-1400轉/分范圍內工作，以使發動機有較大扭距，在運送混凝土過程中，車速不得超過40km/h，以保行車。

12. When the concrete mixer transports the concrete, the engine speed shall be within the range of 1000-1400 rpm, so as to make the engine have a larger torque. In the process of transporting the concrete, the speed shall not exceed 40km / h, so as to ensure the driving safety.

13、混凝土自動上料攪拌車水箱的水量要經常保持裝滿，以備急用，冬季停機后，應將水箱、水泵、水管、攪拌筒內的水放凈，并停放在朝陽、不積水的地方，以免凍壞機械。

13. The water volume of the water tank of the automatic concrete loading mixer shall always be kept full for emergency use. After the mixer stops in winter, the water in the water tank, water pump, water pipe and mixing drum shall be discharged completely, and the mixer shall be parked in the place where there is no water in the morning, so as not to freeze the machinery.

14、攪拌車工作完畢，應把攪拌筒內部和車身清洗干凈，不能使剩余的混凝土留在筒內。

14. After the mixer is completed, the interior and body of the mixing drum shall be cleaned, and the remaining concrete shall not be left in the drum.

15、在冬季應及時安裝保溫套，并使用防凍液對它加以保護，根據天氣變化更換燃油標號，確保機械的正常使用。

15. In winter, the insulation sleeve shall be installed in time, and it shall be protected with antifreeze, and the fuel grade shall be changed according to the weather change to ensure the normal use of the machine.

16、在檢查、修理攪拌車液壓傳動部分時，應使發動機和液壓泵在沒有壓力的情況下進行。

16. When checking and repairing the hydraulic drive part of the mixer, the engine and hydraulic pump shall be operated without pressure.

17、在調整混凝土攪拌車各部間隙、行程、壓力時，應由專職員檢查同意；更換機件時，須由部長或主管經理簽字，否則出現問題后追究有關人員責任。

17. When adjusting the clearance, stroke and pressure of each part of the concrete mixer, the full-time safety officer shall check and approve; when replacing the parts, the director or the manager in charge shall sign, otherwise, the relevant personnel shall be investigated for responsibility.

上一頁：多功能攪拌車使用技巧你知道多少？下一頁：山汽自上料攪拌機降溫的方法有哪些？

熱門產品 / HOT PRODUCT